Throttle cable and harness routing

FZR600 Forum

Moderators: Site Director, FZR Forum Moderators

Post Reply
davephipps
50+ Posts
50+ Posts
Posts: 60
Joined: Mon May 12, 2008 10:50 am
Location: Bloomington Indiana, US

Throttle cable and harness routing

Post by davephipps »

I'm putting the fizzer back together after a bit of electrical work, and am having some routing issues. Does the wiring harness go below or above the carbs? Also, clutch and throttle cables routing info needed. Could someone post a pic of the correct routing.
FZR600 1992
CB550F 1974
GL1000 1978
User avatar
megaloxana
2000+ Posts
2000+ Posts
Posts: 2282
Joined: Thu May 15, 2008 5:05 pm
Location: Hanover, PA 17331
Contact:

Re: Throttle cable and harness routing

Post by megaloxana »

Here are where mine reside

Image
Image

Clutch cable enters the hole in the frame where the electrical harness runs through in the front and then follows the bottom edge of the frame.

Hope that helps.
'92 FZR 600
Airtech R1 kit \*/ 520 conversion \*/ 14F-47R gearing
K&N pod filters \*/ Stage 3 jet kit \*/ Factory Pro shift kit \*/ Full V&H SS exhaust
Custom '02 R6 undertail \*/ YZF gas tank \*/ Raised via dogbones \*/ custom flush turnsignals
Full R6 brake set-up \*/ SS lines \*/ Progressive fork springs \*/ ZX2 coilpack


ADD YOURSELF TO THE OFFICIAL FZRONLINE GOOGLE EARTH MAP :bunny :banjoman
davephipps
50+ Posts
50+ Posts
Posts: 60
Joined: Mon May 12, 2008 10:50 am
Location: Bloomington Indiana, US

Re: Throttle cable and harness routing

Post by davephipps »

WOOHOO :thumbsup: thanks! Sometimes a picture is worth a thousand words.
Now to figure out the clutch cable routing. It's binding the way I have it now banghead
User avatar
megaloxana
2000+ Posts
2000+ Posts
Posts: 2282
Joined: Thu May 15, 2008 5:05 pm
Location: Hanover, PA 17331
Contact:

Re: Throttle cable and harness routing

Post by megaloxana »

davephipps wrote:WOOHOO :thumbsup: thanks! Sometimes a picture is worth a thousand words.
Now to figure out the clutch cable routing. It's binding the way I have it now banghead
Clutch cable is really simple... As it leaves the lever, curve it downward and into the hole in the frame(its like a 1" hole with a plastic bushing around it and wires running through it). Then just run in along the inside of the frame. Mine has plenty of slack.
'92 FZR 600
Airtech R1 kit \*/ 520 conversion \*/ 14F-47R gearing
K&N pod filters \*/ Stage 3 jet kit \*/ Factory Pro shift kit \*/ Full V&H SS exhaust
Custom '02 R6 undertail \*/ YZF gas tank \*/ Raised via dogbones \*/ custom flush turnsignals
Full R6 brake set-up \*/ SS lines \*/ Progressive fork springs \*/ ZX2 coilpack


ADD YOURSELF TO THE OFFICIAL FZRONLINE GOOGLE EARTH MAP :bunny :banjoman
davephipps
50+ Posts
50+ Posts
Posts: 60
Joined: Mon May 12, 2008 10:50 am
Location: Bloomington Indiana, US

Re: Throttle cable and harness routing

Post by davephipps »

Cool. It's on and everything seems to be routed properly. Onto the cantankerous airbox next :swear
Hopefully I'll get this thing back together for the monday morning commute
FZR600 1992
CB550F 1974
GL1000 1978
User avatar
megaloxana
2000+ Posts
2000+ Posts
Posts: 2282
Joined: Thu May 15, 2008 5:05 pm
Location: Hanover, PA 17331
Contact:

Re: Throttle cable and harness routing

Post by megaloxana »

davephipps wrote:Cool. It's on and everything seems to be routed properly. Onto the cantankerous airbox next :swear
Hopefully I'll get this thing back together for the monday morning commute
Glad to hear it. Good luck with the airbox. Remember if you can't get the airbox to go over the carbs, dry a hair dryer/heat gun or dip the airbox in hot water to loosen up the rubber.
'92 FZR 600
Airtech R1 kit \*/ 520 conversion \*/ 14F-47R gearing
K&N pod filters \*/ Stage 3 jet kit \*/ Factory Pro shift kit \*/ Full V&H SS exhaust
Custom '02 R6 undertail \*/ YZF gas tank \*/ Raised via dogbones \*/ custom flush turnsignals
Full R6 brake set-up \*/ SS lines \*/ Progressive fork springs \*/ ZX2 coilpack


ADD YOURSELF TO THE OFFICIAL FZRONLINE GOOGLE EARTH MAP :bunny :banjoman
Post Reply