bike won't start

reelrazor · Post by **reelrazor** » Fri Oct 02, 2009 5:09 pm

Cursed94FZR600 wrote:it does everything but catch. it doesn't have a spark, the coils are good. checked them twice. the pickup is good, according to the resistance.

Is there battery voiltage at the coil primaries (smal wires) when the bike is keyed/switched "on" ?

Cursed94FZR600 · Post by **Cursed94FZR600** » Sun Oct 04, 2009 2:23 pm

OK, so i tested my ingitor on another fzr in stl. the ignitor thing is fine, His bike fired right up. so not really sure what to do next.

reelrazor · Post by **reelrazor** » Sun Oct 04, 2009 3:33 pm

IS THERE BATTERY VOLTAGE AT THE COILS WHEN BIKE IS KEYED AND SWITCED 'ON' ??

Cursed94FZR600 · Post by **Cursed94FZR600** » Sun Oct 04, 2009 8:28 pm

there was last time i checked, middle of last week. the batt is dead right now so I'm charging it was will check again tomorrow.

reelrazor · Post by **reelrazor** » Sun Oct 04, 2009 8:35 pm

Cursed94FZR600 wrote:there was last time i checked, middle of last week. the batt is dead right now so I'm charging it was will check again tomorrow

Just a weird hunch.....put a test light, or multimeter on the DC scale on either the grey, or orange coil lead-and to the frame/engine/ground and key the bike 'on'. (the light should light, or meter should show battery voltage)

When you hit the 'start' button...does the light stay on(meter stay at battery voltage)?

Cursed94FZR600 · Post by **Cursed94FZR600** » Mon Oct 05, 2009 3:20 pm

ok so i just went out. the was voltage coming out of the digital ignitor. but when i tried to start if the

STARTER SWITCH ASY

http://www.cyclepartswarehouse.com/fich ... 4&fveh=590
#9.

it was vibrating and making a funny noise. it could be from the battery voltage being low. i haven't had a chance to pull it and charge it.

is this my problem? do these things go bad? what is it?

reelrazor · Post by **reelrazor** » Mon Oct 05, 2009 3:29 pm

Cursed94FZR600 wrote:ok so i just went out. the was voltage coming out of the digital ignitor. but when i tried to start if the

STARTER SWITCH ASY

http://www.cyclepartswarehouse.com/fich ... 4&fveh=590
#9.

it was vibrating and making a funny noise. it could be from the battery voltage being low. i haven't had a chance to pull it and charge it.

is this my problem? do these things go bad? what is it?

That's teh starter solenoid, and it is NORMAL for them to click/buzz when they aren't getting good voltage.

Post by **sweekster** » Tue Oct 06, 2009 3:00 pm

I have to say...this has gotten waaaaaaay outta hand and waaaaaaaay too complicated. I'm willing to bet the stator/pickup coil has gone bad. Believe it or not that actually happens. As I stated earlier in this thread, if that goes bad it won't start...geez...no one listens.

Cursed94FZR600 · Post by **Cursed94FZR600** » Tue Oct 06, 2009 11:42 pm

but i tested the pickup coil and it tested at ~100 Ohms.

shredex · Post by **shredex** » Wed Oct 07, 2009 1:04 am

if when you hitthe button and the starter solinoid buzzes constantly and only goes away when you turn the ignition off, then you have wrong battery or something. thats what my bike did when I hooked up a sealed battery that went to an r6.

FZRSupport: the FZROnline Archive

bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start

Re: bike won't start